Page 1 of 2 12 LastLast
Results 1 to 20 of 32

Thread: Magnum Calibers and Muzzle Breaks

  1. #1

    Thumbs down Magnum Calibers and Muzzle Breaks

    I there has been some discussions about big caliber guns lately, a lot of people are saying just put a muzzle break on you rifle. I really donít think thatís a good choice: please read below.



    Muzzle Brakes

    By Chuck Hawks



    Newton's law says (to paraphrase) that for every action there must be an equal and opposite reaction. Recoil (kick) is the rifle's reaction to the action of the bullet being accelerated down the rifle barrel. Recoil is caused by two factors. The first is the bullet itself, which cannot be interfered with. The second is the expanding powder gasses that are pushing the bullet and must also exit the barrel. Muzzle brakes reduce recoil by diverting part of these gasses to the side so that they do not add to the rearward recoil.

    A properly designed muzzle brake can significantly reduce recoil. The actual effectiveness depends to an extent on the cartridge for which the rifle is chambered. Ahlman's claims a 50% recoil reduction when their Recoil Reducer muzzle brake is used on large magnum rifles. Mag-na-port International claims recoil reduction of up to 45% for their Mag-na-brake. Browning, whose BOSS (Ballistic Optimizing Shooting System) is both a muzzle brake and an accuracy tuning device, claims a recoil reduction of up to 30%. Weatherby, who claims that their Accubrake is the most effective on the market, claims recoil reduction of up to 53%.

    In their literature, Weatherby compares the effectiveness of the Accubrake to several other makes of muzzle brake. According to Weatherby, who used a .416 Weatherby Magnum rifle for testing, the Recoil Reducer reduced recoil by 39%, the KDF Slimline reduced recoil by 40.6%, and the KDF Regular reduced recoil by 49%. These devices reduced recoil by an average of 42.86%. I find that pretty impressive.

    The Recoil Reducer, Magna-brake, Accubrake and BOSS muzzle brakes are screwed onto the end of the barrel. They are essentially a ventilated steel tube bored a little larger than the groove diameter of the barrel. Screwed firmly into place, they add a couple of inches of length to the end of the barrel, and are usually slightly fatter than the normal outside contour of the barrel. There is no loss of bullet velocity or change in the rifle's ballistic performance with these muzzle brakes.

    The bullet never touches this type of muzzle brake, simply passing through the muzzle brake tube as it leaves the barrel. Some of the expanding powder gas pushing the bullet also passes through the center of the muzzle brake and exits the barrel in a normal manner. But a considerable percentage of the escaping gas finds its way through the holes drilled into the body of the muzzle brake and is deflected outward and at an angle to the rear. This is how these devices reduce recoil. They do work, it is simple physics.

    There is another type of muzzle brake. These are "installed" by porting (drilling or cutting angled holes or slots into) the barrel itself. Such brakes avoid the added length and the slight bulge at the end of the barrel of a screw-on muzzle brake. They are a neater installation and cannot loosen with use. On the other hand, they slightly reduce bullet velocity, tend to collect fouling, make the barrel more difficult to clean, and, most importantly, cannot be removed.

    Mag-na-port cuts a total of four slots into the barrel. The first pair of these are 180 degrees apart on opposite sides of the barrel, starting about 1.5" back from the muzzle. The other pair are 50 degrees apart on the upper surface of the barrel and closer to the muzzle. Mag-na-port claims an average recoil reduction of 15% with their porting system. Other porting systems are said to deliver about a 20% reduction in recoil. Clearly, porting systems are less effective than muzzle brakes attached to the end of the rifle barrel.

    If the advantage of muzzle brakes is reduced recoil, the disadvantage is increased muzzle blast. As always, in the real world, there is no free lunch. The increase in muzzle blast with these devices can be literally deafening, even for shooters wearing hearing protection.

    The muzzle blast from a powerful muzzle brake equipped rifle is so loud that even with hearing protection the shooter risks suffering some permanent hearing damage after a few shots. Earmuff type hearing protectors typically reduce noise by about 25 dB. A muzzle brake equipped magnum rifle (like a .300 or .338 Magnum) produces a sound pressure level (spl) in the 130-dB range, according to reports I have read. Thus the spl inside the hearing protector is in excess of 100 dB, a potentially damaging level.

    For a hunter in the field, shooting without ear protection, the muzzle blast from a muzzle brake is immediately deafening. Nearly complete temporary deafness usually lasts from about a minute to several minutes after firing a powerful magnum rifle equipped with a muzzle brake. Later almost all of the shooter's hearing returns, but a certain amount is permanently lost, and the losses are cumulative.

    This is why hunting rifles equipped with muzzle brakes are illegal in some African jurisdictions. They have proven damaging to the unprotected hearing of the scouts and guides accompanying the hunter. In North America an increasing number of big game guides now refuse to let a sport use a rifle equipped with a muzzle brake for the same reason.

    For the hunter, a muzzle brake that can be removed is the best option. That way it can be used to save the shooter's shoulder when shooting at the range, and removed to help save the shooter's hearing during the hunt.

    Both the Weatherby and Browning devices mentioned above are removable. When the Weatherby Accubrake is unscrewed from the muzzle, a cover ring is screwed on to protect the threads. The Browning BOSS muzzle brake is unscrewed and a solid (no holes) BOSS-CR muzzle weight replaces it. The accuracy tuning function of the BOSS system is thereby retained.

    The muzzle brake tested for this article is a BOSS attached to the barrel of a .338 Winchester Magnum caliber Browning BAR Mark II rifle, which weighs approximately 9 pounds with scope and mount. This rifle was fired from a bench rest at an outdoor rifle range with covered, but not enclosed, firing positions. (It rains a lot in Western Oregon.) The rifle was test fired with both the standard (drilled) BOSS muzzle brake and the solid BOSS-CR (conventional recoil) replacement installed. These are the same length and weight, so there is no difference except for the absence of the muzzle brake effect when the BOSS-CR is used. The test load was Remington Express 225 grain Core-Lokt factory loads with a claimed MV of 2780 fps and ME of 3860 ft. lbs.

    From the shooter's perspective, there is a noticeable reduction in recoil with the drilled BOSS muzzle brake in place. I am inclined to guess about 30%, as Browning claims. In other words, the approximately 29.7 ft. lbs. of free recoil energy is probably reduced to about 20.8 ft. lbs. This means, for example, that the recoil of a BOSS muzzle brake equipped .338 Mag. rifle feels subjectively about like the recoil of a similar 7mm Magnum rifle without the BOSS device (or with a BOSS-CR).

    How a muzzle brake will feel to you, on your rifle, is mostly subjective. The best candidates for a muzzle brake are obviously hard kicking rifles, particularly high velocity magnums that burn a lot of powder. The higher the momentum of the powder gasses being ejected from the muzzle in relation to the momentum of the bullet, the more effective the muzzle brake can be.

    Magnum rifles are generally good candidates for a muzzle brake. For example, Weatherby rifles in the ultra-powerful calibers .378, .416, and .460 Magnum are sold only with the Accubrake installed, which speaks volumes in itself.

    Other rifles chambered for huge magnum calibers, such as the Remington Ultra Mag line of cartridges, are also prime candidates for a muzzle brake. Any lightweight magnum rifle could probably benefit from the installation of a muzzle brake. This includes most of the rifles chambered for the WSM and Remington SAUM lines of short magnum cartridges. (Several Browning models for WSM calibers can be ordered with BOSS.)

    A rifle of adequate weight for its cartridge kicks less than a lightweight model. If a rifle stock fits the shooter well the effect of recoil is minimized. A good recoil pad, such as a Pachmayr Decelerator, softens the effect of recoil; so does a large buttplate. Some rifles, such as the gas operated BAR Mark II used for this test, have a reputation as soft shooting guns and seldom require additional recoil reduction. I prefer the BOSS-CR to the regular BOSS on this rifle, as I find the increase in muzzle blast worse than the recoil.

    Muzzle brakes are controversial devices, because they offer real advantages and entail real disadvantages. As a general guide, I would suggest that hunting rifles, especially those that might be used for hunting dangerous game, should never be ported. If a hunting rifle is equipped with a muzzle brake it should be removable, for the reasons cited above.

    The best answer to the muzzle brake question is simply to avoid calibers that generate more recoil than you can comfortably tolerate. Then you will never need a muzzle brake. Try this. Instead of a .264 Win. Mag., buy a rifle in .260 Rem. or 6.5x55. Instead of a .270 WSM or a .270 Wby. Mag., buy a .270 Winchester. Instead of a 7mm short magnum, buy a 7mm-08. Instead of a standard length 7mm Magnum, buy a .280 Remington. Instead of a .300 short magnum, buy a .308 Winchester. Instead of a standard length .300 Magnum, buy a .30-06. And so on. See, it's easy. You can hunt the same animals and avoid having to make a choice between being kicked out from under your hat or being deafened.

    Please remember that muzzle brakes are exceptionally hard on hearing. Always wear ear protection. Earplugs worn inside of earmuff type hearing protectors are highly recommended when shooting a rifle equipped with a muzzle brake.

  2. #2

    Default

    In air, sound pressure levels above 85 dB are considered harmful, while 95 dB is considered unsafe for prolonged periods and 120 dB causes an immediate perforation of the ear drum.

  3. #3

    Default 30-378 wby muzzle break

    Back in 2002 on a caribou hunt I had 2 guys with me, I had already shot my bou and I was videoing or my partners. Before the hunt started we got into a debate about muzzle breaks. They didnít believe a muzzle break increased noise from shooting roughly 10dbís I told them 10 dB increase in sound level corresponds approximately to a perceived doubling of loudness.
    Long story short I had ear plugs in 10 ft behind the guy when the 1st 30-780 wby (with a break) round was touched off, 4 were fired in a fine display of shooting and the guy next to him shooting at another bou never covered his ears, and was complaining for the next 5 days his ear hurt. I didnít have to explain my point about decibels to him again.

  4. #4
    New member
    Join Date
    Apr 2006
    Location
    Anchorage
    Posts
    493

    Default

    Ive had one on my rifle for probably 20 years, and yes they are louder.But im still keeping mine on,,sorry.Im sold on them..i can shoot all day ,,and not really have any problems.So i guess you dont wanna hunt with me...lol

  5. #5
    Member
    Join Date
    Aug 2006
    Location
    Eagle River,AK
    Posts
    1,488

    Default

    I LOVE my .416 and I LOVE loud rock music.You won't change me!!Hey Bernie1,seem's like you are obsessed with people and their big magnums.Do you close your eye's before pulling the trigger??

  6. #6
    New member mtcop71's Avatar
    Join Date
    Apr 2006
    Location
    Prattville, Alabama, United States
    Posts
    230

    Thumbs up I also

    Love mine, but you knew that already and my partner knows not to stand next to me when I shoot, but we both wear plugs as well, I keep em around my neck and throw em in when ready. I do warn my neighbors at the range and stick to the ends

    Chuck Hawk doesn't like Tikka's either and I love mine as well..

  7. #7
    Member
    Join Date
    Apr 2006
    Location
    Tennessee
    Posts
    3,568

    Default

    I agree with Dan. Yes they are very loud but they work. For range work muffs and plugs are needed. In the field I try to put plugs in before firing. I currently do not own a rifle that has one on but I would not hesitate to have one installed if necessary.
    Rather carry a light big bore with a brake all day than a heavier rifle without one.
    Tennessee

  8. #8
    New member
    Join Date
    Apr 2006
    Posts
    650

    Angry

    both magnum rifles i use for ak. hunting have brakes. i have been using them for 20 years. i shoot better with a pad and a brake installed, so i use them. i keep plugs on my outerwear and buttstock, so they are always accessible.

    i tell the guide ahead of time that i will be using a brake and that he should bring plugs or muffs. if he forgets, i have an extra pair for him. i seem to always find the time before the moment of truth to put them in.

    for range work, i wear sordin 25 n.r.r. muffs and plugs, if shooting under an overhang. i am quite comfortable with this set up.

    as for guides, refusing to take guys with brakes, i always tell the guide up front and have never been discouraged. as for guides who will not take hunters using brakes well, i have not found one yet and i have done quite a bit of hunting in many different locales...
    Last edited by cold zero; 02-21-2007 at 15:22. Reason: spelling

  9. #9

    Talking

    I also I keep plugs around my neck and throw em in when ready, even for my little 30-06

  10. #10
    New member
    Join Date
    Apr 2006
    Posts
    650

    Default

    bernie, that is the smart thing to do, unless you want to walk around with ringing in your ears, tinitis, which i do. it is no fun. protect your ears and eyes, you only have two of each and will not be issued more.

  11. #11
    New member
    Join Date
    Apr 2006
    Location
    Bethel, Cantwell, Fort Yukon, Skagway, Chevak and Point Hope
    Posts
    967

    Default

    Quote Originally Posted by cold zero View Post
    it is no fun. protect your ears and eyes, you only have two of each and will not be issued more.

    I have 2 eyes but only one ear. Lost one in service to my country. :-)

  12. #12
    Member dwhunter's Avatar
    Join Date
    May 2006
    Location
    Texas/Alaska
    Posts
    468

    Default

    I have only owned one rifle with a brake, sold it. I went the better pad and mercury recoil reducer route, much better. I also have service connected hearing loss and I just could not take it.

    Doug

  13. #13
    Member
    Join Date
    Jan 2007
    Location
    Southwest Alaska
    Posts
    2,145

    Default

    Won't have a break on anything. I use muffs and plugs when shooting targets. When out and about, with the possibility of shooting, but still neading to hear, I use my Peltor Tac-Coms. They're waterproof. Perfect for waterfowl hunting.

  14. #14

    Thumbs up mercury

    trailblazersteve
    Nope I keep my eyes wide open when I shoot. Thatís why Iím a good shot haha!

    dwhunter
    Yes! A mercury recoil reducer, thatís what I use on several of my guns it helps reduce recoil without all the negatives of a break. They add about 1 pound to you gun.

  15. #15
    Member dwhunter's Avatar
    Join Date
    May 2006
    Location
    Texas/Alaska
    Posts
    468

    Default

    Bernie1

    Yes and worth every ounce!

    Doug

  16. #16
    Moderator Paul H's Avatar
    Join Date
    Apr 2006
    Location
    Anchorage
    Posts
    5,594

    Default

    I use a past mag recoil pad for range work, works with every gun, and I shoot up to 500 Jeffrey without a break.

    That said, when it comes to mastering shooting I think the best solution is a .223 in the same action style as your hunting gun. There's nothing like something that shoots flat, accurate and has no recoil.

  17. #17
    Member
    Join Date
    May 2006
    Location
    Alaska
    Posts
    2,083

    Default

    One could wear a Past recoil pad over the shoulder, or perhaps replace the stock's pad with a Decelerator recoil pad. I just wear a set of electronic ear muffs when hunting that cuts the noise by 30 decibels. When shooting at the range, I also wear ear plugs under the muffs, and move myself away from other shooters so I don't bother them. I also shoot when not crowded, something that is easy to accomplish early in the morning.

  18. #18
    New member
    Join Date
    Apr 2006
    Location
    Anchorage
    Posts
    493

    Default

    i guess theres lots of "luxuries"..lol,,we dont need on our guns or in our life.But i choose a recoil reducer on my luxury laden gun...lol..

  19. #19
    Member
    Join Date
    Apr 2006
    Location
    SwampView AK, Overlooking Mt. Mckinley and Points Beyond.
    Posts
    8,805

    Default

    My ears are pretty sensitive, probably from not using ear protection in my younger days.

    I hate muzzle brakes. I can't see myself hunting with someone who uses a brake. I leave the range if someone is shooting with one.

    I like soft recoil pads, Past shields, 26 inch barrels, and sitting upright at the shooting bench.

    My biggest rifle is a 338, but if I wanted a bigger one, I'd just make sure it was heavy, had a long barrel, and a wide soft butt pad.

    JMO. To each is own, but what about responsibility?

    Smitty of the North

  20. #20
    Member
    Join Date
    Feb 2007
    Location
    Los Anchorage
    Posts
    481

    Default

    I have a muzzle break on my rifle. I had to put it on so I didn't start to flinch. It was the best thing that I have ever done to any of my guns. It is loud don't get my wrong. When I sight it in on the range I use two pairs of ear plugs. I try to get away from everyone. For the people that complain they are to loud at the range I'm sorry. It is a lot better then the person that there with an **** rifle that is shooting 30 rounds faster then I get three off. I can shot a box of shells if need be without a black and blue shoulder.
    Last edited by Murphy; 02-22-2007 at 07:55. Reason: Selection of words

Page 1 of 2 12 LastLast

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •